Inactivation of Listeria monocytogenes and Salmonella spp. During Cooking of Country Ham and Fate of L. monocytogenes and Staphylococcus aureus During Storage of Country Ham Slices.

Thermal inactivation studies were undertaken on Listeria monocytogenes and Salmonella spp. inoculated on the surface of country ham. Hams (average = ca. 3.4 ± 0.5 kg each; average = ca. ≥18% shrinkage) were used as provided by the processor (i.e., "salted hams"), desalted in tap water (i.e., "desalted hams"), or dried for an additional period (i.e., "extra-dried hams"). Hams were surface inoculated (ca. 9.5 log CFU/ham) with a multistrain cocktail of L. monocytogenes or Salmonella spp. and cooked within a bag ina circulating water bath to an internal temperature of 130°F (54.4°C) instantaneous, 145°F (62.8°C) and held for 4 min, 153°F (67.2°C) and held for 34 s, or 160°F (71.1°C) instantaneous. Regardless of ham type, all four time and temperature combinations tested herein delivered a ≥6.7-log reduction of cells of L. monocytogenes or Salmonella spp. Differences in product pH, moisture content, or aw did not have an appreciable impact on the thermal inactivation of L. monocytogenes or Salmonella spp. on country ham. In addition, shelf-life studies were undertaken using slices of "salted" country ham that were surface inoculated (ca. 5.5 log CFU/slice) with a multistrain cocktail of L. monocytogenes or Staphylococcus aureus and then stored at 20°C. Levels of S. aureus increased by ca. ≤1.4 log CFU/slice during storage for 90 days, whereas levels of L. monocytogenes remained relatively unchanged (≤0.2 log CFU/slice increase). Our data validated that cooking parameters elaborated in the U.S. Department of Agriculture's Food Safety and Inspection Service Cooking Guideline for Meat and Poultry Products (Revised Appendix A) are sufficient to deliver significant reductions (ca. ≥6.8 log CFU/ham) in levels of L.monocytogenes and Salmonella spp. on country ham. In addition, in the event of postprocessing contamination, country ham may support the outgrowth of S. aureus or survival of L. monocytogenes during storage at 20°C for 90 days.

Fate of Listeria monocytogenes, Salmonella spp., and Shiga Toxin-Producing Escherichia coli on Slices of an All-Beef Soppressata during Storage.

Cells of Listeria monocytogenes, Salmonella spp., or Shiga toxin-producing Escherichia coli (STEC) were inoculated (ca. 4.0 log CFU/slice) onto slices (ca. 4 g each slice) of an all-beef soppressata (ca. pH 5.05 and aw 0.85). The storage of vacuum-sealed slices of inoculated soppressata at 4 °C or 20 °C for 90 days resulted in reductions of all three pathogens by ca. 2.2 to 3.1 or ca. ≥3.3 log CFU/slice, respectively. When pathogen levels decreased to below detection (≤1.18 log CFU/slice) by direct plating, it was possible to recover each of the target pathogens by enrichment, albeit more frequently from slices stored at 4 °C (p < 0.05) compared to 20 °C. In summary, the slices of the commercially produced beef soppressata selected for this study did not provide a favorable environment for either survival or outgrowth of surface-inoculated cells of L. monocytogenes, Salmonella spp., or STEC during storage.

Viability of Listeria monocytogenes and Salmonella spp. on Slices of a German-Style Bologna Containing Blends of Organic Acid Salts During Storage at 4 or 12°C.

Viability of cells of Listeria monocytogenes or Salmonella spp. was quantified on slices of a German-style bologna manufactured by a local butcher to contain no added antimicrobials or to include 0.9% or 1.3% of a blend of potassium acetate and sodium diacetate (K-Ace) or 2.5% of a blend of potassium lactate and sodium diacetate (K-Lac) as ingredients. After slicing (ca. 7.1 cm L by 6.7 cm W, ca. 0.5 cm thick, ca. 22.4 g each), a single slice of bologna was placed into a nylon-polyethylene bag and surface inoculated with 250 µL per side of a five-strain mixture of either cells of L. monocytogenes or Salmonella spp. to achieve an initial level of ca. 3.5-4.0 log CFU/slice. The packages were vacuum-sealed and then stored at 4 or 12°C for 90 and 30 days, respectively. Without antimicrobials added to the formulation, L. monocytogenes numbers increased by ca. 5.4 and 6.0 log CFU/slice at both 4 and 12°C during the entire 90- and 30-day storage period, respectively. Likewise, levels of Salmonella also increased by ca. 6.0 log CFU/slice at 12°C in the absence of added antimicrobials; however, levels of this pathogen decreased by ca. 1.7 log CFU/slice after 90 days at 4°C. With the inclusion of 0.9% or 1.3% K-Ace or 2.5% K-Lac in the bologna formulation, levels of L. monocytogenes decreased by ca. ≤0.7 log CFU/slice after 90 days at 4°C, whereas levels of Salmonella decreased by ca. 1.6-2.3 log CFU/slice. After 30 days at 12°C, levels of L. monocytogenes increased by ca. ≤3.4 log CFU/slice on product containing 0.9% K-Ace or 2.5% K-Lac but remained relatively unchanged on slices formulated with 1.3% K-Ace. For Salmonella, in the presence of 0.9% or 1.3% K-Ace or 2.5% K-Lac, pathogen levels decreased by ca. ≤0.7 log CFU/slice at 12°C after 30 days. Our data validate that the inclusion of K-Ace (0.9% or 1.3%) or K-Lac (2.5%) as ingredients is effective for controlling L. monocytogenes and Salmonella on slices of bologna during refrigerated storage.

Meat Bars: A Survey To Assess Consumer Familiarity and Preparation Parameters and a Challenge Study To Quantify Viability of Shiga Toxin-Producing Escherichia coli Cells during Processing and Storage.

Meat bars are dried snacks containing a mixture of meat, berries, and nuts. To explore consumer awareness of meat bars, we conducted two online, nationally representative surveys and established that 70.8% (743 of 1,050) of U.S. citizens were unfamiliar with this product. When asked to check all answers that applied, most of the 545 respondents (who were recruited based on their familiarity with meat bars) preferred beef (n = 385) as the protein source, followed by chicken (n = 293), pork (n = 183), and turkey (n = 179). Most meat bars were purchased from grocery stores (n = 447), followed by online orders (n = 130) and outdoor stores (n = 120). When asked specifically whether they made their own meat bars, 17.8% of respondents (97 of 545) replied "yes," the majority (52 of 97, 54%) of which obtained recipes online. Some 69.1% (67 of 97) measured the internal temperature of the meat during dehydration, but only 10.3% (10 of 97) confirmed the internal temperature by using a thermometer. Given the paucity of information available on the fate of pathogenic or spoilage bacteria associated with meat bars, as another component of this study, batter was prepared with or without encapsulated citric acid (ECA; 0.74%) added to a formulation of ground beef (65%; 90% lean, 10% fat), chopped pecans (15%), golden flaxseed flour (9.7%), chopped cranberries (5.0%), chopped sunflower seeds (3.1%), sea salt (1.1%), black pepper (0.8%), and celery powder (0.35%). Batter was inoculated (ca. 6.5 log CFU/g) with Shiga toxin-producing Escherichia coli (STEC), portioned by hand (40 ± 0.1 g each), and then dried in a commercial dehydrator. Regardless of the drying treatment, inclusion of ECA in the batter resulted in a pH decrease from ca. 5.5 to ca. 4.7 to 5.0 in the finished product. Without ECA, when meat bars were dried at 62.8°C for 6 h, 71.1°C for 4 h, or 62.8°C for 2 h and then 71.1°C for 2 h, levels of STEC decreased by ca. 6.2, 6.3, or 5.2 log CFU/g, respectively. With ECA, STEC decreased by ca. 6.0, 6.6, or 6.0 log CFU/g in meat bars dried at 62.8°C for 6 h, 71.1°C for 4 h, or 62.8°C for 2 h and then 71.1°C for 2 h, respectively. Our results confirmed that a ≥5.0-log reduction in STEC could be achieved in meat bars formulated with or without ECA under all dehydration conditions tested.

Evaluation of post-fermentation heating times and temperatures for controlling Shiga toxin-producing Escherichia coli cells in a non-dried, pepperoni-type sausage.

Coarse ground meat was mixed with non-meat ingredients and starter culture (Pediococcus acidilactici) and then inoculated with an 8-strain cocktail of Shiga toxin-producing Escherichia coli (ca. 7.0 log CFU/g). Batter was fine ground, stuffed into fibrous casings, and fermented at 35.6°C and ca. 85% RH to a final target pH of ca. pH 4.6 or ca. pH 5.0. After fermentation, the pepperoni-like sausage were heated to target internal temperatures of 37.8°, 43.3°, 48.9°, and 54.4°C and held for 0.5 to 12.5 h. Regardless of the heating temperature, the endpoint pH in products fermented to a target pH of pH 4.6 and pH 5.0 was pH 4.56±0.13 (range of pH 4.20 to pH 4.86) and pH 4.96±0.12 (range of pH 4.70 to pH 5.21), respectively. Fermentation alone delivered ca. a 0.3- to 1.2-log CFU/g reduction in pathogen numbers. Fermentation to ca. pH 4.6 or ca. pH 5.0 followed by post-fermentation heating to 37.8° to 54.4°C and holding for 0.5 to 12.5 h generated total reductions of ca. 2.0 to 6.7 log CFU/g.

Behavior of Listeria monocytogenes on Mortadella Formulated Using a Natural, Clean-Label Antimicrobial Agent during Extended Storage at 4 or 12°C.

All-pork mortadella, an Italian-style deli meat, was produced by a local artisanal meat producer with or without 1.0 or 1.5% liquid buffered vinegar (LBV), 0.4, 0.6, or 1.0% dry buffered vinegar (DBV), or a 2.5% blend of potassium lactate and sodium diacetate (KLac). In each of three trials, mortadella was sliced (ca. 1.5 cm thick, ca. 30 g) and surface inoculated with 250 µL per side of a five-strain mixture of Listeria monocytogenes (ca. 3.8 log CFU per slice). The packages were vacuum sealed and then stored at 4 or 12°C. In the absence of antimicrobials, L. monocytogenes levels increased by ca. 2.6 and 6.0 log CFU per slice after up to 120 or 28 days at 4 or 12°C, respectively. With inclusion of 1.0 or 1.5% LBV, 1.0% DBV, or 2.5% KLac as ingredients, pathogen levels decreased by ca. 0.3 to 0.7 log CFU per slice after 120 days at 4°C, whereas with inclusion of 0.4 or 0.6% DBV, L. monocytogenes levels increased by ca. 1.2 and 0.8 log CFU per slice, respectively. After 28 days at 12°C, inclusion of 2.5% KLac, 1.0 or 1.5% LBV, or 0.4 or 0.6% DBV resulted in a ca. 1.4- to 5.7-log increase in L. monocytogenes levels. When 1.0% DBV was included in the formulation, pathogen levels remained unchanged after 28 days at 12°C. However, product quality was lessened at this abusive storage temperature (12°C) for all treatments by the end of storage. Thus, inclusion of LBV or DBV, as clean-label ingredients, in mortadella is equally effective as KLac for controlling L. monocytogenes during storage at 4°C without adversely affecting product quality.

Viability of Listeria monocytogenes on Boneless, Water-Added Hams, Commercially Prepared with and without Food-Grade Chemicals, during Extended Storage at 4 and/or -2.2°C.

Viability of Listeria monocytogenes was monitored during refrigerated (4°C) and/or frozen (i.e., deep chilling at -2.2°C) storage on casing-cooked hams that were commercially prepared with and without potassium lactate and sodium diacetate (1.6%), buffered vinegar (2.2%), buffered vinegar and potassium lactate (1.7%), or a blend of potassium lactate, potassium acetate, and sodium diacetate (1.7%). A portion of these hams were subsequently surface treated with lauric arginate ester (LAE; 44 ppm). In phase I, hams (ca. 3.5 kg each) were sliced (ca. 0.7 cm thick, ca. 100 g), inoculated (ca. 4.0 log CFU per slice), surface treated with LAE, and stored at either 4°C for 120 days or at -2.2°C for 90 days and then at 4°C for an additional 120 days. In phase I, without antimicrobials, the population of L. monocytogenes increased by ca. 5.9 log CFU per slice within 120 days at 4°C; however, pathogen levels increased only slightly (ca. 0.45 log CFU per slice) for hams formulated with potassium lactate and sodium diacetate and decreased by ca. 1.2 log CFU per slice when formulated with the other antimicrobials. For slices held at -2.2°C and then stored at 4°C, but not treated with LAE, L. monocytogenes increased by ca. 4.5 log CFU per slice for controls, whereas when formulated with antimicrobials, pathogen levels decreased by ca. 1.4 to 1.8 log CFU per slice. For product treated with LAE, L. monocytogenes increased by ca. 4.0 log CFU per slice for controls, whereas when formulated with antimicrobials, pathogen levels decreased by ca. 0.9 to 1.9 log CFU per slice. In phase II, whole hams (ca. 1.0 kg each) containing antimicrobials were inoculated (6.8 log CFU per ham) and then stored at -2.2°C for 6 months. Pathogen levels decreased by ca. 2.0 to 3.5 log CFU per ham (without LAE treatment) and by ca. 4.2 to 5.2 log CFU per ham (with application of LAE via Sprayed Lethality in Container) when product was held at -2.2°C. In general, deep chilling hams was listericidal, and inclusion of antimicrobials in the formulation suppressed outgrowth of L. monocytogenes during extended cold storage.

Comparative Efficacy of Potassium Levulinate with and without Potassium Diacetate and Potassium Propionate versus Potassium Lactate and Sodium Diacetate for Control of Listeria monocytogenes on Commercially Prepared Uncured Turkey Breast.

We evaluated the efficacy of potassium levulinate (KLEV; 0.0, 1.0, 1.5, and 2.0%) with and without a blend of potassium propionate (0.1%) and potassium diacetate (0.1%) (KPD) versus a blend of potassium lactate (1.8%) and sodium diacetate (0.125%) (KLD) for inhibiting Listeria monocytogenes on commercially prepared, uncured turkey breast during refrigerated storage. Product formulated with KLD or KLEV (1.5%) was also subsequently surface treated with 44 ppm of a solution of lauric arginate (LAE). Slices (ca. 1.25 cm thick and 100 g) of turkey breast formulated with or without antimicrobials were surface inoculated on both the top and bottom faces to a target level of ca. 3.5 log CFU per slice with a five-strain cocktail of L. monocytogenes, vacuum sealed, and then stored at 4°C for up to 90 days. Without inclusion of antimicrobials in the formulation, pathogen levels increased by ca. 5.2 log CFU per slice, whereas with the inclusion of 1.0 to 2.0% KLEV pathogen levels increased by only ca. 2.9 to 0.8 log CFU per slice after 90 days at 4°C. When 1.0% KLEV and KPD were included as ingredients, pathogen levels increased by ca. 0.8 log CFU per slice after storage at 4°C for 90 days, whereas a decrease of ca. 0.7 log CFU per slice was observed when 1.5 or 2.0% KLEV and KPD were included as ingredients. When used alone, KPD was not effective (≥5.8-log increase). As expected, KLD was effective at suppressing L. monocytogenes in uncured turkey breast. When uncured turkey breast was formulated with KLD or KLEV (1.5%) or without antimicrobials and subsequently surface treated with LAE, pathogen levels decreased by ca. 1.0 log CFU per package within 2 h; no differences (P ≥ 0.01) were observed in pathogen levels for product surface treated with or without LAE and stored for 90 days. Our results validate the use of KLEV to inhibit outgrowth of L. monocytogenes during refrigerated storage of uncured turkey breast. KLEV is at least as effective as KLD as an antilisterial agent.

Utilization of buffered vinegar to increase the shelf life of chicken retail cuts packaged in carbon dioxide.

Poultry processors commonly place whole parts of broilers in plastic packages and seal them in an atmosphere of 100% carbon dioxide before shipping them to food service and retail customers. This practice extends the shelf life of retail cuts to approximately 12 d under refrigerated conditions. The objective of this study was to determine the antimicrobial efficacy of vinegar for growth inhibition of mesophilic and lactic acid bacterial counts and enhancement of shelf life in CO2-packaged refrigerated chicken thigh samples. Meat quality, sensory differences, and microbial enumeration were evaluated for chicken thighs that were sprayed with 0, 0.5, or 1.0% vinegar. No differences were observed (P > 0.05) among treatments (control vs. 0.5 and 1.0% vinegar-treated chicken thighs) with respect to pH and Commission Internationale d'Eclairage L*a*b*for both chicken skin and the meat tissue. The difference from the control test indicated that trained panelists were not able to detect a difference (P > 0.05) in flavor between the chicken thigh treatments. The mesophilic and Lactobacillus bacterial counts were enumerated after 0, 4, 8, 12, 16, and 20 d of storage. The mesophilic bacterial load for the 1.0% vinegar treatment was less than all other treatments after 8, 12, 16, and 20 d of storage, whereas the 0.5% vinegar treatment had lower bacterial counts at d 12 than both controls and had an approximate shelf life of 16 d. For lactic acid bacteria, the vinegar 1.0% treatment had lower counts than the control treatments at d 12 and 16. The results from the study indicate that a combination of 1.0% vinegar with CO2 packaging can extend the shelf life from 12 to 20 d for chicken retail cuts without negatively affecting the quality and sensory properties of the broiler meat.

Viability of Listeria monocytogenes on uncured turkey breast commercially prepared with and without buffered vinegar during extended storage at 4 and 10°C.

We determined the viability of Listeria monocytogenes on uncured turkey breast containing buffered vinegar (BV) and surface treated with a stabilized solution of sodium chlorite in vinegar (VSC). Commercially produced, uncured, deli-style turkey breast was formulated with BV (0.0, 2.0, 2.5, or 3.0%), sliced (ca. 100 g and ca. 1.25 cm thick), and subsequently surface inoculated (ca. 4.3 log CFU per slice) in each of two trials with a five-strain cocktail of L. monocytogenes. Next, 1 ml per side of a 2 or 10% solution of VSC was added to each package before vacuum sealing and storing at 4 or 10°C. Without antimicrobials, L. monocytogenes numbers increased by ca. 6.2 log CFU per slice after 90 and 48 days of storage at 4 or 10°C, respectively. At 4°C, L. monocytogenes numbers increased by ca. 0.4 to 1.9 log CFU per slice on turkey breast formulated with 2.0 or 2.5% BV and treated or not with 2% VSC, whereas when treated with 10% VSC, L. monocytogenes levels remained relatively unchanged over 90 days. However, when turkey breast was formulated with 3.0% BV and treated or not with VSC, pathogen numbers decreased by ca. 0.7 to 1.3 log CFU per slice. At 10°C, L. monocytogenes numbers increased by ca. 1.5 to 5.6 log CFU per slice after 48 days when formulated with 2.0 to 3.0% BV and treated or not with 2% VSC. When formulated with 2.0% BV and treated with 10% VSC, L. monocytogenes numbers increased by ca. 3.3 log CFU per slice, whereas when formulated with 2.5 or 3.0% BV and treated with 10% VSC, L. monocytogenes decreased by ca. 0.3 log CFU per slice. Inclusion of BV as an ingredient in uncured turkey breast, alone or in combination with VSC added to the package, appreciably suppressed outgrowth of L. monocytogenes during an extended refrigerated shelf life.

Potassium acetate and potassium lactate enhance the microbiological and physical properties of marinated catfish fillets.

Sodium or potassium salts such as lactate and acetate can be used to inhibit the growth of spoilage bacteria and food-borne pathogens, and thereby prolong the shelf-life of refrigerated seafood. However, minimal information is available regarding the combined effects of potassium salts (acetate and lactate) with an agglomerated phosphate blend on the quality and safety of refrigerated catfish fillets. The objective of this study was to determine the microbiological and quality characteristics of marinated catfish fillets treated with organic acid salts. Catfish fillets were vacuum-tumbled with a brine solution with and without the added organic acid salts, at 10% over initial, raw weight prior to tray-packing and storage at 4 °C for 14 d. Fillets were evaluated for yields, color, pH, tenderness, consumer acceptability, and shelf-life. No differences (P > 0.05) existed among the treated and untreated fillets with regards to solution pick-up and pH, but all treated fillets increased (P < 0.05) cooking yields and Intl. Commission on Illumination (CIE) a* values, and decreased (P < 0.05) CIE L* and b* values in the catfish fillets when compared to the untreated fillets. The fillets treated with a combination of potassium acetate and potassium lactate had lower (P < 0.05) psychrotrophic plate counts and lower spoilage scores than the control treatments on days 7, 10, and 14. In addition, consumers preferred (P < 0.05) treated catfish fillets (fried) with respect to appearance, flavor, and overall acceptability over the negative control. In conclusion, the combination of potassium acetate and potassium lactate enhanced sensory quality and extended the shelf-life of refrigerated catfish fillets.